我們在結束每日的生產活動后為了降低中空玻璃雙組份打膠機故障率提供生產我們必須做到以下幾點

　　Following the end of the daily production activities, in order to reduce the failure rate of the hollow glass double component breaker, we must do the following

　　1、雙組份打膠機每次使用完畢，要將機器上的殘膠及灰塵清除干凈，使機器保持清潔。

　　1, two sets of glue machine, after each use, the machine will be residual glue and dust clean, make the machine keep clean.

　　2、不定期的應全面檢查各緊固件是否有松動現象，并重新緊固。建議每個三天進行一次排查!

　　2, irregular, should be fully checked whether the fasteners are loose, and re tightened. It is recommended to have an investigation every three days!

　　3、清理混膠器及其前后管道內的凝結膠，定期清理止回閥;發現阻力增高或者堵塞現象，要及時清理。

　　3, cleaning glue mixer and its pipe before and after the coagulation gel, regular cleaning check valve; found resistance increased or blocked phenomenon, should promptly clean up.

　　2、定期檢查電氣接線是否有松動及接地可靠性。

　　2 、 regularly check whether the electrical wiring is loose and the reliability of the grounding.

　　其實不單單是中空玻璃雙組份打膠機我們身邊的其他設備也同樣需要定期的維護保養，設備其實同我們人一樣，你只要真心的、認真的對待他呵護她，設備也會盡心盡力的為您做付出大的力量來給你帶來大的收益。

　　In fact, not only is the other equipment of hollow glass two-component glue machine around us also need regular maintenance equipment, in fact we like people, as long as you treat him, care for her, the equipment will also dedicated for you do pay a maximum power to benefit you.

　　3、要有足夠的壓力。同時，連接管路時要注意不可超過接頭牙面并消除管接內的各種金屬微塵類污垢。

　　3, there should be enough pressure. At the same time, pay attention not to exceed the joint tooth surface when connecting the pipeline, and eliminate all kinds of metal dust like dirt in the pipe connection.

　　平時在維護保養的時候只要做到連接管路的清潔以及注意接頭是否完好規矩即可。

　　Usually in maintenance, as long as the connection pipe cleaning, and pay attention to whether the joints are intact, rules can.

　　4、修理時要打開電磁閥的閥芯，并且要注意更換密封圈，同時要要在每次清理過后加入少量潤滑油后再裝入。

　　4, repair the solenoid valve to open the valve, and pay attention to the replacement of sealing ring, and at the same time after each cleaning, add a small amount of lubricating oil and then loaded.

　　反之如果你沒有對設備進行認真的呵護維護他同樣會以各種方式來表達不滿，比如設備故障罷工!

　　On the other hand, if you do not take care of the equipment seriously, he will also express his dissatisfaction in various ways, such as equipment failure and strike!

　　本文由雙組份打膠機為您提供，我們的網站是:http://www.yalais.com/我們將以全心全意的熱情為您提供更優質的服務，歡迎您的訪問!

　　This article is made up of a two component press machine. Our website is: http://www.yalais.com/, we will provide you with better service with your wholehearted enthusiasm, and welcome your visit!